Effect of a cold quarantine treatment on physiological disorders and quality of cactus pear fruit

Salvatore D’Aquino; Daniela Satta; Luciano De Pau; Amedeo Palma; Salvatore D’Aquino; Daniela Satta; Luciano De Pau; Amedeo Palma

doi:10.3934/agrfood.2019.1.114

AIMS Agriculture and Food

2019, Volume 4, Issue 1: 114-126. doi: 10.3934/agrfood.2019.1.114

Previous Article Next Article

Research article Special Issues

Effect of a cold quarantine treatment on physiological disorders and quality of cactus pear fruit

1.
Institute of Sciences of Food Production, National Research Council, Sassari, Italy
2.
Agris Sardegna, Agricultural Research Agency of Sardinia—Department of Wood and Food Tree, Cagliari, Italy

Received: 04 October 2018 Accepted: 15 January 2019 Published: 23 January 2019

Despite Italy is second only to Mexico for fresh production of cactus pears worldwide, postharvest handling and treatments are quite simply, being fruit immediately marketed after harvest. However, as the demand for fresh fruit beyond the harvesting period is constantly growing, in the next future the cactus pear industry likely will have to adopt postharvest treatments and technologies that can widen the marketable window. Yet, the potential exploitation of new markets in countries where the introduction of pests like Mediterranean fruit fly are considered risky, can be achieved only if fruit are subjected to approved quarantine protocols. Of the three main cultivated varieties (‘Bianca’, ‘Gialla’ and ‘Rossa’) limited studies concerning cold storage have been done mainly on fruit of cv ’Gialla’, while knowledge on response to cold quarantine treatments lacks for all cultivars. Thus this study was undertaken to get knowledge on postharvest behavior of the three main Italian cultivated cactus pears varieties, i.e. ‘Bianca’, ‘Gialla’ and ‘Rossa’ subjected to a cold quarantine treatment followed by either a week of simulated marketing conditions at 20 °C or by two additional weeks of storage at 8 °C before transfer to simulated marketing conditions at 20 °C for three days. These storage conditions so far are not practiced by packing houses as fruit are directly marketed after harvest, but could be a typical protocol in case fruit should be sold in countries that require approved cold quarantine treatments.
Results showed an abnormal increase in respiratory activity and ethylene production rates following transfer from cold storage to 20 °C, especially after the two additional weeks of storage at 8 °C. Peel disorders and decay incidence were slight at the end of storage at 2 °C or 8 °C, but severe peel disorders developed when fruit were moved to 20 °C. Peel injury, decay incidence, the loss of overall appearance upon transfer to 20 °C were more severe in fruit stored for two additional weeks at 8 °C. Among the three cultivars, susceptibility to chilling injury and decay was higher in cv ‘Bianca’. Nevertheless, cold storage seems not to affect the chemical and sensory quality of fruit, whose changes were similar in all cultivars.
- cactus pear,
- ethylene production,
- physiological disorders,
- juice acidity,
- respiratory activity,
- weight loss
Citation: Salvatore D’Aquino, Daniela Satta, Luciano De Pau, Amedeo Palma. Effect of a cold quarantine treatment on physiological disorders and quality of cactus pear fruit[J]. AIMS Agriculture and Food, 2019, 4(1): 114-126. doi: 10.3934/agrfood.2019.1.114

Related Papers:

Abstract

Despite Italy is second only to Mexico for fresh production of cactus pears worldwide, postharvest handling and treatments are quite simply, being fruit immediately marketed after harvest. However, as the demand for fresh fruit beyond the harvesting period is constantly growing, in the next future the cactus pear industry likely will have to adopt postharvest treatments and technologies that can widen the marketable window. Yet, the potential exploitation of new markets in countries where the introduction of pests like Mediterranean fruit fly are considered risky, can be achieved only if fruit are subjected to approved quarantine protocols. Of the three main cultivated varieties (‘Bianca’, ‘Gialla’ and ‘Rossa’) limited studies concerning cold storage have been done mainly on fruit of cv ’Gialla’, while knowledge on response to cold quarantine treatments lacks for all cultivars. Thus this study was undertaken to get knowledge on postharvest behavior of the three main Italian cultivated cactus pears varieties, i.e. ‘Bianca’, ‘Gialla’ and ‘Rossa’ subjected to a cold quarantine treatment followed by either a week of simulated marketing conditions at 20 °C or by two additional weeks of storage at 8 °C before transfer to simulated marketing conditions at 20 °C for three days. These storage conditions so far are not practiced by packing houses as fruit are directly marketed after harvest, but could be a typical protocol in case fruit should be sold in countries that require approved cold quarantine treatments.
Results showed an abnormal increase in respiratory activity and ethylene production rates following transfer from cold storage to 20 °C, especially after the two additional weeks of storage at 8 °C. Peel disorders and decay incidence were slight at the end of storage at 2 °C or 8 °C, but severe peel disorders developed when fruit were moved to 20 °C. Peel injury, decay incidence, the loss of overall appearance upon transfer to 20 °C were more severe in fruit stored for two additional weeks at 8 °C. Among the three cultivars, susceptibility to chilling injury and decay was higher in cv ‘Bianca’. Nevertheless, cold storage seems not to affect the chemical and sensory quality of fruit, whose changes were similar in all cultivars.

References

[1]	Ochoa MJ, Barbera G (2017) History and economic and agro-ecological importance, In: Inglese P, Mondragon C, Nefzaoui A, et al., Crop Ecology, Cultivation and Uses of Cactus Pear, Rome: The Food and Agriculture Organization of the United Nations and the International Center for Agricultural Research in the Dry Areas, 1–11.
[2]	Potgieter J, D'Aquino S (2017) Fruit production and post-harvest management, In: Inglese P, Mondragon C, Nefzaoui A, et al., Crop Ecology, Cultivation and Uses of Cactus Pear, Rome: The Food and Agriculture Organization of the United Nations and the International Center for Agricultural Research in the Dry Areas, 51–72.
[3]	Cantwell M (1995) Post-harvest management of fruits and vegetable stems, In: Barbera G, Inglese P, Pimienta Barrios E, et al., Agro-ecology, cultivation and uses of cactus pear, Rome: FAO Plant Production and Protection Paper No. 132, 120–141.
[4]	Yahia EM, Saenz C (2011) Cactus pear (Opuntia species), In: Yahia EM, Postharvest biology and technology of tropical and subtropical fruits Vol. 2, Cambridge: Woodhead Publishing, 290–329.
[5]	Liguori G, Inglese P (2015) Cactus pear (O. ficus-indica (L.) Mill.) fruit production: ecophysiology, orchard and fresh−cut management. Acta Hortic 1067: 247–252.
[6]	Inglese P, Basile F, Schirra M (2002) Cactus pear fruit production, In: Nobel PS, Cacti: Biology and uses, Berkeley: University of CaliforniaPress, 163–184.
[7]	Patel S (2013) Reviewing the prospects of Opuntia pears as low cost functional foods. Rev Environ Sci Biotechnol 12: 223–234. doi: 10.1007/s11157-012-9295-6
[8]	Schirra M, Barbera G, D'Aquino S, et al. (1996) Hot dips and high-temperature conditioning to improve shelf quality of late-crop cactus pear fruit. Tropical Science 36: 159–165.
[9]	Schirra M, Agabbio M, D'Aquino S, et al. (1997) Postharvest heat conditioning effects on early ripening 'Gialla' cactus pear fruit. Hortscience 32: 702–704. doi: 10.21273/HORTSCI.32.4.702
[10]	Piga A, D'Aquino S, Agabbio M, et al. (1996). Storage life and quality attributes of cactus pears cv 'Gialla' as affected by packaging. Agricoltura Mediterranea 126: 423–427.
[11]	D'Aquino S, Chessa I, Inglese P, et al. (2017) Increasing cold tolerance of cactus pear fruit by high-temperature conditioning and film wrapping. Food Bioprocess Technol 10: 1466–1478. doi: 10.1007/s11947-017-1917-0
[12]	Lyons MJ, Breidenbach RW (1990) Relation of chilling stress to respiration, In: Wang CY, Chilling injury of horticultural crops, Boca Raton: CRC Press, 223–233.
[13]	McCollum TG, McDonald RE (1991) Electrolyte leakage, respiration, and ethylene production as indices of chilling injury in grapefruit. HortScience 26: 1191–1192. doi: 10.21273/HORTSCI.26.9.1191
[14]	Wang CY (2010) Alleviation of chilling injury in tropical and subtropical fruits. Acta Hortic 864: 264–273.
[15]	D'Aquino S, Chessa I, Schirra M (2014) Heat Treatment at 38 °C and 75–80 % Relative Humidity Ameliorates Storability of Cactus Pear Fruit (Opuntia ficus-indica cv 'Gialla'). Food Bioprocess Technol 7: 1066–1077. doi: 10.1007/s11947-013-1111-y
[16]	D'Aquino S, Palma A, Schirra M, et al. (2015) Decay control of cactus pear by pre- and post-cold storage and water at 50 °C. Acta Hortic 1067: 119–125.
[17]	Pantastico EB, Soule J, Grierson W (1968) Chilling injury in tropical and subtropical fruits: II. limes and grapefruit. Amer Soc Hort Sci Caribbean Reg Proc 12: 171–183.
[18]	Jackman RL, Yada RY, Marangoni A, et al. (1988) Chilling injury: a review of qualitative aspects. J Food Qual 11: 253–278. doi: 10.1111/j.1745-4557.1988.tb00887.x
[19]	Schirra M, Brandolini V, Cabras P, et al. (2002) Thiabendazole uptake and storage performance of cactus pear [Opuntia ficus-indica (L.) Mill. Cv Gialla] fruit following postharvest treatments with reduced doses of fungicide at 52 °C. J Agric Food Chem 50: 739–743.
[20]	Cantwell M (2016) Prickly pear, In: Gross KC, Wang CY, Saltveit M, The commercial storage of fruits, vegetables, and florist and nursery stocks, USDA, ARS, Agricultural Handboob 66. Washington DC., 511–513.
[21]	Wang CY (2016). Chilling and Freezing Injury, In: Gross KC, Wang CY, Saltveit M, The commercial storage of fruits, vegetables, and florist and nursery stocks, USDA, ARS, Agricultural Handboob 66. Washington DC., 62–67.
[22]	Palma A, Continella A, La Malfa S, et al. (2018) Changes in physiological and some nutritional, nutraceuticals, chemical-physical, microbiological and sensory quality of minimally processed cactus pears cvs 'Bianca', 'Gialla' and 'Rossa' stored under passive modified atmosphere. J Sci Food Agric 98: 1839–1849. doi: 10.1002/jsfa.8660
[23]	Pimienta-Barrios E (1994) Prickly Pear (Opuntia spp.): a valuable fruit crop for the semi-arid lands of Mexico. J Arid Environ 28: 1–11.
[24]	Kyriacou MC, Emmanouilidou MG, Soteriou GA (2016) Asynchronous ripening behavior of cactus pear (Opuntia ficus-indica) cultivars with respect to physicochemical and physiological attributes. Food Chem 211: 598–607. doi: 10.1016/j.foodchem.2016.05.113

Reader Comments

Your name:*

Email:*
© 2019 the Author(s), licensee AIMS Press. This is an open access article distributed under the terms of the Creative Commons Attribution License (http://creativecommons.org/licenses/by/4.0)