A thermal responsive affinity ligand for precipitation of sialylated proteins

Lindsay Arnold; Tian-Bo Yang; Rachel Chen; Lindsay Arnold; Tian-Bo Yang; Rachel Chen

doi:10.3934/bioeng.2016.1.92

AIMS Bioengineering

2016, Volume 3, Issue 1: 92-102. doi: 10.3934/bioeng.2016.1.92

Previous Article Next Article

Research article

A thermal responsive affinity ligand for precipitation of sialylated proteins

School of Chemical and Biomolecular Engineering, Georgia Institute of Technology, Atlanta, GA30332-0100, USA

Received: 17 November 2015 Accepted: 13 January 2016 Published: 25 January 2016

We report here the development of a thermal responsive affinity ligand specific to sialic acid, sialic acid containing oligosaccharides, glycoproteins, and other sialylated glycoconjugates. The ligand is a fusion protein of 40 repeats of pentapeptide of an elastin like polymer (ELP) and the 21 kD sialic acid binding domain of a Vibrio cholera neuraminidase (VCNA). For cost-effective synthesis, the fusion protein was targeted to the periplasmic space of an E. coli lpp deletion mutant, resulting in its secretion to the growth medium. A pre-induction heat-shock step at 42 ˚C for 20 minutes was necessary to achieve high level expression of the ligand. Under optimized induction condition (18 ˚C, 0.1 mM IPTG and 48 hours of post-induction cultivation), the ligand was produced to about 100 mg/L. The ligand exhibited a transition temperature of 52 ˚C, which could be depressed to 37 ˚C with the addition of 0.5 M NaCl. Using fetuin as a model sialylated protein, the ligand was applied in an affinity precipitation process to illustrate its potential application in glycoprotein isolation. The ligand captured 100% fetuin from an aqueous solution when the molar ratio of ligand to fetuin was 10 to 1, which was lower than the expected for full titration of sialic acid on the glycoprotein by the lectin. Elution of fetuin from ligand was achieved with PBS buffer containing 2 mM sialic acid. To evaluate how protein and other contaminants influence the recovery of sialylated proteins, CHO medium was spiked into the fetuin solution. The predominant protein species in CHO medium was found to be albumin. Although its removal of over 94% was evident, purified fetuin contained some albumin due to its over-abundance. Additional experiments with albumin contaminant of varying concentrations showed that below 1 mg/L, albumin had no impact on the affinity precipitation, whereas above 10 mg/L, some albumin was co-purified with fetuin. However, even at 50 mg/ml, fetuin recovery yield remained high (about 90%) and about 95% of albumin was depleted with only one cycle of precipitation and elution. These results suggest that the ligand could be used in initial capture of sialylated proteins and to remove over-abundant albumin contaminant. To the best of our knowledge, this is the first thermal responsive sialic acid binding protein developed with gene fusion technology.
- Albumin depletion,
- Glycoprotein purification,
- affinity precipitation,
- sialylated proteins,
- thermal-responsive lectin
Citation: Lindsay Arnold, Tian-Bo Yang, Rachel Chen. A thermal responsive affinity ligand for precipitation of sialylated proteins[J]. AIMS Bioengineering, 2016, 3(1): 92-102. doi: 10.3934/bioeng.2016.1.92

Related Papers:

Abstract

We report here the development of a thermal responsive affinity ligand specific to sialic acid, sialic acid containing oligosaccharides, glycoproteins, and other sialylated glycoconjugates. The ligand is a fusion protein of 40 repeats of pentapeptide of an elastin like polymer (ELP) and the 21 kD sialic acid binding domain of a Vibrio cholera neuraminidase (VCNA). For cost-effective synthesis, the fusion protein was targeted to the periplasmic space of an E. coli lpp deletion mutant, resulting in its secretion to the growth medium. A pre-induction heat-shock step at 42 ˚C for 20 minutes was necessary to achieve high level expression of the ligand. Under optimized induction condition (18 ˚C, 0.1 mM IPTG and 48 hours of post-induction cultivation), the ligand was produced to about 100 mg/L. The ligand exhibited a transition temperature of 52 ˚C, which could be depressed to 37 ˚C with the addition of 0.5 M NaCl. Using fetuin as a model sialylated protein, the ligand was applied in an affinity precipitation process to illustrate its potential application in glycoprotein isolation. The ligand captured 100% fetuin from an aqueous solution when the molar ratio of ligand to fetuin was 10 to 1, which was lower than the expected for full titration of sialic acid on the glycoprotein by the lectin. Elution of fetuin from ligand was achieved with PBS buffer containing 2 mM sialic acid. To evaluate how protein and other contaminants influence the recovery of sialylated proteins, CHO medium was spiked into the fetuin solution. The predominant protein species in CHO medium was found to be albumin. Although its removal of over 94% was evident, purified fetuin contained some albumin due to its over-abundance. Additional experiments with albumin contaminant of varying concentrations showed that below 1 mg/L, albumin had no impact on the affinity precipitation, whereas above 10 mg/L, some albumin was co-purified with fetuin. However, even at 50 mg/ml, fetuin recovery yield remained high (about 90%) and about 95% of albumin was depleted with only one cycle of precipitation and elution. These results suggest that the ligand could be used in initial capture of sialylated proteins and to remove over-abundant albumin contaminant. To the best of our knowledge, this is the first thermal responsive sialic acid binding protein developed with gene fusion technology.

References

[1]	Lightfoot EN, Cockrem MCM (2013) Complex Fitness Diagrams: Downstream Processing of Biologicals. Sep Sci Technol 48(12): 1753–7.
[2]	Jungbauer A (1993) Review: Preparative chromatography of biomolecules. J Chromatogr 639: 3–16. doi: 10.1016/0021-9673(93)83082-4
[3]	Patchornik G, Albeck A (2005) Free nonimmobilized ligands as a tool for purification of proteins. Bioconjug Chem 16(5): 1310–5.
[4]	Meyer DE, Chilkoti A (1999) Purification of recombinant proteins by fusion with thermally-responsive polypeptides. Nat Biotechnol 17: 1112–5. doi: 10.1038/15100
[5]	Linné-Larsson E, Galaev I, Lindahl L, et al. (1996) Affinity precipitation of Concanavalin A with p-aminophenyl- α-D-glucopyranoside modified Eudragit S-100. Bioseparation 6: 273–282.
[6]	Liu F, Tsai SL, Madan B, et al. (2012) Engineering a high-affinity scaffold for non-chromatographic protein purification via intein-mediated cleavage. Biotechnol Bioeng 109: 2829–35. doi: 10.1002/bit.24545
[7]	Fong B, Wu W, Wood DW (2009) Optimization of ELP-intein mediated protein purification by salt substitution. Protein Expr Purif 66: 198–202. doi: 10.1016/j.pep.2009.03.009
[8]	Arnold L, Chen R (2014) Novel thermo-responsive fucose binding ligands for glycoprotein purification by affinity precipitation. Biotechnol Bioeng 111(2): 413–7.
[9]	Arnold L, Chen R (2015) One-step non-chromatography purification of a low abundant fucosylated protein from complex plant crude extract. AIMS Bioeng 2: 249–263. doi: 10.3934/bioeng.2015.3.249
[10]	Sethuraman N, Stadheim T (2006) Challenges in therapeutic glycoprotein production. Curr Opin Biotechnol 17(4): 341–6.
[11]	Misaizu T, Matsuki S, Strickland TW, et al. (1995) Role of antennary structure of N-linked sugar chains in renal handling of recombinant human erythropoietin. Blood 86(11): 4097–104.
[12]	Skibeli V (2001) Sugar profiling proves that human serum erythropoietin differs from recombinant human erythropoietin. Blood 98(13): 3626–34.
[13]	Shin H-D, Chen RR (2008) Extracellular recombinant protein production from an Escherichia coli lpp deletion mutant. Biotechnol Bioeng 101(6): 1288–96.
[14]	Crennell S, Garman E, Laver G, et al. (1994) Crystal structure of Vibrio cholerae neuraminidase reveals dual lectin-like domains in addition to the catalytic domain. Structure 2(6): 535–44.
[15]	Moustafa I, Connaris H, Taylor M, et al. (2004) Sialic acid recognition by Vibrio cholerae neuraminidase. J Biol Chem 279(39): 40819–26.
[16]	Spiro RG (1960) Studies on fetuin, a glycoprotein of fetal serum. J Biol Chem 235: 2860–9.
[17]	Eriksson C, Schwenk JM, Sjoberg A, et al. (2011) Affibody molecule-mediated depletion of HAS and IgG using different buffer compositions: a 15 min protocol for parallel processing of 1-48 samples. Biotechnol Appl Biochem 56: 49–57.
[18]	Haudenschild DR, Eldridge A, Lein PJ, et al. (2014) High abundant protein removal from rodent blood for biomarker discovery. Biochem Biophys Res Commun 455: 84–9. doi: 10.1016/j.bbrc.2014.09.137

Reader Comments

Your name:*

Email:*
© 2016 the Author(s), licensee AIMS Press. This is an open access article distributed under the terms of the Creative Commons Attribution License (http://creativecommons.org/licenses/by/4.0)