Improved biological wastewater treatment and sludge characteristics by applying magnetic field to aerobic granules

Yong-Qiang Liu; Sri Suhartini; Liang Guo; Yeping Xiong; Yong-Qiang Liu; Sri Suhartini; Liang Guo; Yeping Xiong

doi:10.3934/bioeng.2016.4.412

AIMS Bioengineering

2016, Volume 3, Issue 4: 412-424. doi: 10.3934/bioeng.2016.4.412

Previous Article Next Article

Research article

Improved biological wastewater treatment and sludge characteristics by applying magnetic field to aerobic granules

1.
Faculty of Engineering and the Environment, University of Southampton, Southampton, SO17 1BJ, United Kingdom
2.
College of Environmental Science and Engineering, Ocean University of China, Qingdao 266100, P.R.China

Received: 01 September 2016 Accepted: 13 October 2016 Published: 24 October 2016

Permanent magnets with non-uniform magnetic field and an electromagnet with 3–5 mT uniform magnetic field were applied to investigate their effects on both aerobic granulation and COD and ammonium removal in reactors with less than 7% coverage of magnetic field. It was found that both types of magnets had little influence on the granulation speed and the settling ability of granular sludge at the steady state. However, the maximum specific COD degradation rate and the maximum specific NH4⁺-N removal rate were increased by 45–54% and 30–50%, respectively, in the magnetic fields. Mean effluent COD with the electromagnet and the permanent magnet field, respectively, at the steady state, was 28 mg l⁻¹ and 6 mg l⁻¹, respectively, lower than the control at a statistical significance level of alpha = 0.05. No statistically significant increase in NH4⁺-N removal was observed at the steady state probably due to almost complete NH4⁺-N removal before the end of the cycle. In addition, it was found that extracellular polymeric substances in granular sludge with electromagnet were 77% more while soluble microbial products were much less compared with the control, suggesting a positively changed metabolism of granular sludge at steady state. The results in this study indicated that low-intensity magnetic field has a great potential to be applied in granular sludge for an improved wastewater treatment.
- waste-water treatment; biodegradation; heterotrophs; aggregation; aerobic granules; magnetic field
Citation: Yong-Qiang Liu, Sri Suhartini, Liang Guo, Yeping Xiong. Improved biological wastewater treatment and sludge characteristics by applying magnetic field to aerobic granules[J]. AIMS Bioengineering, 2016, 3(4): 412-424. doi: 10.3934/bioeng.2016.4.412

Related Papers:

Abstract

Permanent magnets with non-uniform magnetic field and an electromagnet with 3–5 mT uniform magnetic field were applied to investigate their effects on both aerobic granulation and COD and ammonium removal in reactors with less than 7% coverage of magnetic field. It was found that both types of magnets had little influence on the granulation speed and the settling ability of granular sludge at the steady state. However, the maximum specific COD degradation rate and the maximum specific NH4⁺-N removal rate were increased by 45–54% and 30–50%, respectively, in the magnetic fields. Mean effluent COD with the electromagnet and the permanent magnet field, respectively, at the steady state, was 28 mg l⁻¹ and 6 mg l⁻¹, respectively, lower than the control at a statistical significance level of alpha = 0.05. No statistically significant increase in NH4⁺-N removal was observed at the steady state probably due to almost complete NH4⁺-N removal before the end of the cycle. In addition, it was found that extracellular polymeric substances in granular sludge with electromagnet were 77% more while soluble microbial products were much less compared with the control, suggesting a positively changed metabolism of granular sludge at steady state. The results in this study indicated that low-intensity magnetic field has a great potential to be applied in granular sludge for an improved wastewater treatment.

References

[1]	Cakmak T, Cakmak ZE, Dumlupinar R, et al. (2012) Analysis of apoplastic and symplastic antioxidant system in shallot leaves: Impacts of weak static electric and magnetic field. J Plant Physiol 169: 1066–1073. doi: 10.1016/j.jplph.2012.03.011
[2]	Nawrotek P, Fijalkowski K, Struk M, et al. (2014) Effects of 50 Hz rotating magnetic field on the viability of Escherichia coli and Staphylococcus aureus. Electromagn Biol Medicine 33: 29–34.
[3]	Utsunomiya T, Yamane Y, Watanabe M, et al. (2003) Stimulation of Porphyrin Production by Application of an External Magnetic Field to a Photosynthetic Bacterium. Rhodobacter sphaeroides J Biosci Eng 95: 401–404.
[4]	Chen H, Li X (2008) Effect of static magnetic field on synthesis of polyhydroxyalkanoates from different short-chain fatty acids by activated sludge. Bioresour Technol 99: 5538–5544 . doi: 10.1016/j.biortech.2007.10.047
[5]	Lebkowska M, Rutkowska-Narozniak A, Pajor E, et al. (2011) Effect of a static magnetic field on formaldehyde biodegradation in wastewater by activated sludge. Bioresour Technol 102: 8777–8782. doi: 10.1016/j.biortech.2011.07.040
[6]	Kriklavova L, Truhlar M, Skodovaa P, et al. (2014) Effects of a static magnetic field on phenol degradation effectiveness and Rhodococcus erythropolis growth and respiration in a fed-batch reactor. Bioresour Technol 167: 510–513. doi: 10.1016/j.biortech.2014.06.060
[7]	Pospisilova D, Schreiberova O, Jirku V, et al. (2015) Effects of Magnetic Field on Phenol Biodegradation and Cell Physiochemical Properties of Rhodococcus erythropolis. Biorem J 19: 201–206. doi: 10.1080/10889868.2015.1029114
[8]	Zaidi N S, Sohaili J, Muda K, et al. (2014) Magnetic Field Application and its Potential in Water and Wastewater Treatment Systems. Sep Purif Rev 43: 206–240. doi: 10.1080/15422119.2013.794148
[9]	Filipic J, Kraigher B, Tepus B, et al. (2015) Effect of Low-Density Static Magnetic Field on the Oxidation of Ammonium by Nitrosomonas europaea and by Activated Sludge in Municipal Wastewater. Food Technol Biotechnol 53: 201–206.
[10]	Moura AAO, Terra NM, Borges WS, et al. (2015) Influence of an electromagnetic field on the bioreduction of chromium (VI) using a mixed culture of microorganisms, Environ Prog Sustain Energy 34: 88–98.
[11]	Hattori S, Watanabe M, Osono H, et al. (2001) Effects of an external magnetic field on the flock size and sedimentation of activated sludge. World J Microbiol Biotechnol 17: 833–838. doi: 10.1023/A:1013811114017
[12]	Tomska A, Wolny L (2008) Enhancement of biological wastewater treatment by magnetic field exposure. Desalination 222: 368–373. doi: 10.1016/j.desal.2007.01.144
[13]	Wang XH, Diao MH, Yang Y, et al. (2012) Enhanced aerobic nitrifying granulation by static magnetic field. Bioresour Technol 110: 105–110. doi: 10.1016/j.biortech.2012.01.108
[14]	Kong Y, Liu YQ, Tay JH, et al. (2009) Aerobic granulation in sequencing batch reactors with different reactor height/diameter ratios. Enzyme Microb Technol 45: 379–383. doi: 10.1016/j.enzmictec.2009.06.014
[15]	Chen FY, Liu YQ, Tay JH, et al. (2011) Operational strategies for nitrogen removal in granular sequencing batch reactor. J Hazard Mater 189: 342–348. doi: 10.1016/j.jhazmat.2011.02.041
[16]	APHA (2005) Standard methods for the examination of water and wastewater. American Public Health Association, Washington DC, USA.
[17]	Bradford MM (1976) A rapid and sensitive method for the quantitation of microgram quantities of protein utilizing the principle of protein-dye binding. Anal Biochem 72: 248–254. doi: 10.1016/0003-2697(76)90527-3
[18]	Dubois M, Gilles KA, Hamilton JK, et al. (1956) Calorimetric method for determination of sugars and related substances. Anal Chem 28: 350–356. doi: 10.1021/ac60111a017
[19]	Lan H, Chen R, Ma P, et al. (2015) Cultivation and characteristics of micro-aerobic activated sludge with weak magnetic field. Desalination Water Treatment 53: 27–35. doi: 10.1080/19443994.2013.834272
[20]	Liu YQ, Tay JH (2015) Fast formation of aerobic granules by combining strong hydraulic selection pressure with overstressed organic loading rate. Water Res 80: 256–266. doi: 10.1016/j.watres.2015.05.015
[21]	Liu YQ, Kong YH, Tay JH, et al. (2011) Enhancement of start-up of pilot-scale SBR fed with real wastewater. Sep Purif Technol 82: 190–196. doi: 10.1016/j.seppur.2011.09.014
[22]	Lebkowska M, Narożniak-Rutkowska A, Pajor E (2013) Effect of a static magnetic field of 7 mT on formaldehyde biodegradation in industrial wastewater from urea–formaldehyde resin production by activated sludge. Bioresour Technol 132: 78–83. doi: 10.1016/j.biortech.2013.01.020
[23]	Yavuz H, Celebi SS (2000) Effects of magnetic field on activity of activated sludge in wastewater treatment. Enzyme Microb Technol 26: 22–27. doi: 10.1016/S0141-0229(99)00121-0
[24]	Hu X, Dong HY, Qiu ZN, et al. (2007) The effect of high magnetic field characterized by kinetics: Enhancing the biodegradation of acid red 1 with a strain of Bacillus sp. Internat Biodeter Biodegrad 60: 293–298.
[25]	Filipic J, Kraigher B, Tepus B, et al. (2012) Effects of low-density static magnetic fields on the growth and activities of wastewater bacteria Escherichia coli and Pseudomonas putida. Bioresour Technol 120: 225–232. doi: 10.1016/j.biortech.2012.06.023
[26]	Niu C, Geng J, Ren H, et al. (2013) The strengthening effect of a static magnetic field on activated sludge activity at low temperature. Bioresour Technol 150: 156–162.
[27]	Neyens E, Baeyens J, Dewil R, et al. (2004) Advanced sludge treatment affects extracellular polymeric substances to improve activated sludge dewatering. J Hazard Mater 106B: 83–92.
[28]	Liu YQ, Liu Y, Tay JH (2004) The effects of extracellular polymeric substances on the formation and stability of biogranules. Appl Microbiol Biotechnol 65: 143–148.
[29]	Zhou Y, Li J, Wei S (2011) Dewaterability of aerobic granular sludge. Appl Mechanics Mater 90–93: 2944–2948.
[30]	Drews A (2010) Membrane fouling in membrane bioreactors—Characterisation, contradictions, cause and cures. J Membr Sci 363: 1–28. doi: 10.1016/j.memsci.2010.06.046
[31]	Liu Y, Wang ZW, Liu YQ, et al. (2005) A generalized model for settling velocity of aerobic granular sludge. Biotechnol Prog 21: 621–626.
[32]	Van Loosdrecht M, Lin Y, Lotti T (2016) Extracellular polymers from granular sludge as sizing agents. US patent 20160230345.
[33]	Barker DJ, Stuckey DC (1999) A review of soluble microbial products (SMP) in wastewater treatment systems. Water Res 33: 3063–3082. doi: 10.1016/S0043-1354(99)00022-6
[34]	Han S, Jin W, Chen Y, et al. (2016) Abomohra A.E, Enhancement of lipid production of Chlorella Pyrenoidosa cultivated in municipal wastewater by magnetic treatment. Appl Biochem Biotechnol doi:10.1007/s12010-016-2151-3.

Reader Comments

Your name:*

Email:*
© 2016 the Author(s), licensee AIMS Press. This is an open access article distributed under the terms of the Creative Commons Attribution License (http://creativecommons.org/licenses/by/4.0)